煤基多孔炭膜去除压载水中微藻的研究

doi:10.3724/SP.J.1077.2013.12761

无机材料学报 ›› 2013, Vol. 28 ›› Issue (10): 1067-1071.DOI: 10.3724/SP.J.1077.2013.12761

煤基多孔炭膜去除压载水中微藻的研究

宋成文¹, 陶平¹, 宋学凯², 吴帅华¹, 邵秘华¹, 高光锐¹, 冯祎宁¹, 王同华²

(1. 大连海事大学环境科学与工程学院, 大连 116026; 2. 大连理工大学化工学院, 精细化工国家重点实验室炭素研究室, 大连 116012)

收稿日期:2012-12-17 修回日期:2013-01-21 出版日期:2013-10-20 网络出版日期:2013-09-18
作者简介:宋成文(1975?), 男, 副教授. E-mail: songchengwen_dmu@yahoo.com.cn
基金资助:
国家自然科学基金(20776024, 20836006, 20976021, 21276035); 国家863项目(2009AA03Z215); 辽宁省海洋与渔业厅海洋环保专题基金(2012-Inhyhbc-0004, 2012-Inhyhbc-0005); 海洋赤潮灾害立体监测技术与应用国家海洋局重点实验室开放研究基金(MATHAB200916); 中央高校基本科研业务费专项基金(3132013085)

Removal of Microalgae in Ballast Water by Coal-based Porous Carbon Membrane

SONG Cheng-Wen¹, TAO Ping¹, SONG Xue-Kai², WU Shuai-Hua¹, SHAO Mi-Hua¹, GAO Guang-Rui¹, FENG Yi-Ning¹, WANG Tong-Hua²

(1. School of Environment Science and Engineering, Dalian Maritime University, Dalian 116026, China; 2. Carbon Research Laboratory and State Key Laboratory of Fine Chemicals, School of Chemical Engineering, Dalian University of Technology, Dalian 116012, China)

Received:2012-12-17 Revised:2013-01-21 Published:2013-10-20 Online:2013-09-18
About author:SONG Cheng-Wen. E-mail: songchengwen_dmu@yahoo.com.cn
Supported by:
National Natural Science Foundation of China (20776024, 20836006, 20976021, 21276035); National High-tech Research and Development Project of China (2009AA03Z215); Special Foundation for Ocean Environmental Protection of Ocean and Fisheries Department of Liaoning Province (2012-Inhyhbc-0004, 2012-Inhyhbc-0005); Foundation of Key Laboratory of Integrated Monitoring and Applied Technologies for Marine Harmful Algal Blooms, S.O.A. (MATHAB200916); Fundamental Research Funds for the Central Universities (3132013085)

摘要/Abstract

摘要： 针对船舶压载水转移所引起的外来生物入侵问题, 开发了以廉价煤为原料经挤压成型、炭化等工艺制备出煤基管状多孔炭膜。分别采用扫描电镜和气体泡压技术对煤基炭膜的微观形貌和孔结构特性进行表征, 并详细考察了压载水处理过程中微藻种类、跨膜压差、错流速率以及微藻密度对处理效果的影响。实验结果表明, 煤基炭膜表面光滑, 孔隙结构发达, 孔径均一, 这非常有利于处理压载水中微藻。压载水中微藻尺寸越大, 膜的稳定通量越小; 增大跨膜压差, 膜的稳定通量增幅变缓, 尤其对含有小球藻和叉鞭金藻的模拟压载水, 因其尺寸与炭膜平均孔径相近, 容易受压变形进入膜孔形成膜内污染, 变缓程度更为明显; 增大错流流速可增大膜表面剪切力, 减少微藻在膜表面堆积, 提高炭膜的稳定通量; 提高藻液密度, 加重膜表面污染, 降低膜的稳定通量。经炭膜处理后, 渗透液中均未检出微藻的存在, 显示出煤基多孔炭膜在船舶压载水处理领域具有潜在的应用前景。

关键词: 煤, 炭膜, 压载水, 微藻

Abstract: Introduction of invasive species via ballast water has been identified as one of the greatest threats to oceans. The coal-based porous carbon membrane with low cost for removal of microalgae in ballast water was prepared by carbonization of tubular carbonaceous precursor obtained by extrusion method. Scanning electron microscopy and bubble-pressure method were employed to investigate the morphology and pore structure characteristics of carbon membrane. Effects of microalgae size, transmembrane pressure and crossflow velocity on the steady-state flux were also studied. The results indicate that the as-prepared carbon membrane has smooth surface, rich and uniform porous structure, which are beneficial for removing microalgae in ballast water. A decrease in steady-state flux is observed as the microalgae size increases. High transmembrane pressure is more prone to block the membrane pore and results in the decrease of the steady-state flux. High crossflow velocity is favorable to increase the steady-state flux owing to the inhibition of fouling layer development through the high shear stress on membrane surface. After being treated by coal-based carbon membrane, no microalgae are detected. It indicates that coal-based carbon membrane is of great potential to ballast water treatment.

Key words: coal, carbon membrane, ballast water, microalgae

中图分类号:

O643

宋成文, 陶平, 宋学凯, 吴帅华, 邵秘华, 高光锐, 冯祎宁, 王同华. 煤基多孔炭膜去除压载水中微藻的研究[J]. 无机材料学报, 2013, 28(10): 1067-1071.

SONG Cheng-Wen, TAO Ping, SONG Xue-Kai, WU Shuai-Hua, SHAO Mi-Hua, GAO Guang-Rui, FENG Yi-Ning, WANG Tong-Hua. Removal of Microalgae in Ballast Water by Coal-based Porous Carbon Membrane[J]. Journal of Inorganic Materials, 2013, 28(10): 1067-1071.

参考文献

[1] Drake L A, Doblin M A, Dobbs F C. Potential microbial bioinvasions via ships' ballast water, sediment, and biofilm. Marine Pollution Bulletin, 2007, 55(7/8/9): 333-341.

[2] Flagella M M, Verlaque M, Soria A, et al. Macroalgal survival in ballast water tanks. Marine Pollution Bulletin, 2007, 54(9): 1395-1401.

[3] Gollasch S, David M, Voigt M, et al. Critical review of the IMO international convention on the management of ships’ ballast water and sediments. Harmful Algae, 2007, 6(4): 585–600.

[4] Mamlook R, Badran O, Abu-Khader M M, et al. Fuzzy sets analysis for ballast water treatment systems: best available control technology. Clean Techn Environ Policy, 2008, 10(4): 397–407.

[5] Champ M A. Marine Testing Board for certification of ballast water treatment technologies. Marine Pollution Bulletin, 2002, 44(12): 1327-1335.

[6] Ismail A F, David L I B. A review on the latest development of carbon membranes for gas separation. J. Membr. Sci., 2001, 193(1): 1-18 .

[7] LI Lin, WANG Tong-Hua, CAO Yi-Ming, et al. Physical design, preparation and functionalization of carbon membranes for gas separation. Journal of Inorganic Materials, 2010, 25(5): 449-456.

[8] Song C W, Wang T H, Qiu J S. Pore structure prediction of coal-based microfiltration carbon membranes. Materials Science, 2010, 55(13): 1325-1330.

[9] WANG Tong-Hua, WEI Wei, LIU Shu-Qin, et al. The study on tubular porous carbon membrane. New Carbon Materials, 2000, 15(1): 6-11.

[10] Song C W, Wang T H, Qiu J S, et al. Effects of carbonization conditions on the properties of coal-based microfiltration carbon membranes. Journal of Porous Materials, 2008, 15(1): 1-6.

[11] Arkhangelsky E, Gitis V. Effect of transmembrane pressure on rejection of viruses by ultrafiltration membranes. Separation and Purification Technology, 2008, 62(3): 619-628.

[12] Thomassen J K, Faraday D B F, Underwood B O, et al. The effect of varying transmembrane pressure and crossflow velocity on the microfiltration fouling of a model beer. Separation and Purification Technology, 2005, 41(1): 91-100.

[13] Ahmad A L, Ismail S, Bhatia S. Membrane treatment for palm oil mill effluent: effect of transmembrane pressure and crossflow velocity. Desalination, 2005, 179(1/2/3): 245-255.

[1]	李君, 曹亚丽, 王鲁香, 贾殿赠. 煤基球形多孔碳用于锂离子电池负极材料的性能研[J]. 无机材料学报, 2017, 32(9): 909-915.
[2]	徐国忠, 金文武, 曾燮榕, 邹继兆, 熊信柏, 黄麟, 赵振宁. 煤基炭泡沫孔结构调控[J]. 无机材料学报, 2016, 31(9): 961-968.
[3]	张兵, 江园, 吴永红, 鲁云华, 赵丹丹, 王同华. 高氢渗透分离性的沸石杂化支撑炭膜的制备[J]. 无机材料学报, 2016, 31(3): 257-262.
[4]	李金宏, 周岐雄, 米红宇, 李显, 李惠萍. 基于煤萃取物的类石墨状多孔炭的制备及其电容性能研究[J]. 无机材料学报, 2016, 31(1): 39-46.
[5]	解小玲, 曹青, 郭良辰, 钟存贵. 石墨烯晶种法制备有序针状焦及电化学性研究[J]. 无机材料学报, 2014, 29(9): 979-984.
[6]	孙美悦, 李琳, 张萍萍, 徐家家, 郁焦竹, 王同华. P25杂化炭膜的制备及其气体分离性能[J]. 无机材料学报, 2013, 28(5): 485-489.
[7]	孟凡宁, 王春雷, 武明星, 林逍, 王同华, 马廷丽. 染料敏化太阳能电池无FTO煤基炭对电极的研究[J]. 无机材料学报, 2013, 28(3): 273-277.
[8]	庞婧, 王同华, 李琳, 祁文博, 曹义鸣. 不同干燥方式对聚醚砜酮基炭膜的影响[J]. 无机材料学报, 2011, 26(2): 165-159.
[9]	于建国, 王玉璋, 翁史烈. 煤气组分对固体氧化物燃料电池碳沉积的影响[J]. 无机材料学报, 2011, 26(11): 1129-1135.
[10]	李琳1, 王同华1, 曹义鸣2, 邱介山1. 气体分离炭膜的结构设计、制备及功能化[J]. 无机材料学报, 2010, 25(5): 449-456.
[11]	赵选英,王同华,李琳,刘颖,曹义鸣. Fe₃O₄掺杂制备气体分离功能炭膜[J]. 无机材料学报, 2010, 25(1): 47-52.
[12]	吴德意,孔海南,赵统刚,王崇,叶春. 合成条件对粉煤灰合成沸石过程中沸石生成和品质的影响[J]. 无机材料学报, 2005, 20(5): 1153-1158.
[13]	杜爱兵,刘旭光,许并社. 煤基纳米洋葱状富勒烯制备及其结构表征[J]. 无机材料学报, 2005, 20(4): 779-784.
[14]	张海军,刘战杰,钟香崇. 煤矸石还原氮化合成O’-Sialon及热力学研究[J]. 无机材料学报, 2004, 19(5): 1129-1137.
[15]	王晓刚,牟国栋,李晓池,陈维,陈寿田. 煤矸石的纳米结构及其对合成SiC的影响[J]. 无机材料学报, 2001, 16(4): 715-719.

煤基多孔炭膜去除压载水中微藻的研究

Removal of Microalgae in Ballast Water by Coal-based Porous Carbon Membrane

RichHTML

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价